![]() |
EDUCATION | CATALOG | RIGGING | CONSULTATION | HOME | CONTACT US |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
![]() Been Hard at work removing two of my chainplates in a Passport 42 cutter. worst thing
i have had to do to my boat yet. old chainplates are fiberglassed in place in a kinda H shape. had to cut out the lovely teak backs, of the salon cabinets to access them. two plates on starboard were right at cabinet bulkheads. very depressing. used a Rigid Multitool to cut out the fiberglass covering. found that you must use the metal and wood saws, as the wood only blades turn into scraper blades far to quickly. while cutting out the chainplates i hit 3 pockets of water on the starboard plate, and 5 on the port. nasty black ooze drained out. when i finally got the plates off the port side the knee was all black on the bottom. tried to drill drainage holes but the wood was way to spongy or rotten. even the wood that initially looked ok on both sides was spongy, i could almost push the drill bit in without pulling the trigger. i then cut one of the fiberglass sides of the knee on both sides and they pretty much just fell out. obviously these were not installed correctly and fiberglassed on every side, one of the knees did not even go all the way to the deck and had a gap of about 2". the wood looks like fir, but its so bad i cant be sure. its a simple job to replace them, but i need to know what wood i can use to do so. should i go get some blocks of fir, Ironwood(IPE), Mahogany, or would Oak be a better choice? what about replacing it all with a block of G10 Fiberglass epoxied into place? i have a decent piece of oak that may be about the right size. not sure which way to proceed here. Thanks Robert |
Thread Tools | |
Display Modes | |
|
|